Poor Quality Def Duramax, Heater failures, 2012 Duramax w/ exhaust fluid quality poor Need your input everyone. Rarely, if ever, is it actually due to 'bad def' -- def can be tested with a refractometer. 2 days later it changes to NOX sensor check engine light. Few days later I get an intermittent poor DEF quality on and off. The series of DEF Quality Warnings alert the driver that DEF system service is urgently needed. If the test fails, replace the DEF. I got a Duramax! With def Cruze with def DEF limp mode/exhaust poor quality limp/speed restriction fix! I have a 2015 chev Cruze diesel but this is the same for a duramax with def system, Dreaded DEF poor quality A week and a half ago I was driving down the express way and got the DEF poor quality message on the DIC. GM Duramax diesel DEF tank failures are increasingly popping up in social media and owners are furious about the problems around the issues with Service DEF > Replaced Tank > Poor DEF Quality Jump to Latest 766 views 10 replies 3 participants last post by Snipesy Mar 12, 2025 W The L5P Duramax DEF (Diesel Exhaust Fluid) system has been the #1 cause of unexpected limp-mode and check-engine lights on 2017–2025 Silverado/Sierra 2500HD/3500HD trucks. The necessary steps include completely draining the DEF tank to eliminate the poor Exhaust fluid quality poor see owner's manual now Looking for advice. It's a Chevrolet Silverado 2500HD with approximately 100,000 miles on it. A simple reset isn't usually a fix. Warning Level 1 Warning Level 1 is triggered when the ECM first detects the SCR efficiency Hal : DEF fluid can deteriorate over time. Should I replace the NOX sensors, Def injector and tank again? Still having problems. The I have a 2024 Chevy 2500HD Duramax with only 24,000 miles on the truck. This message suggests that the quality of the DEF fluid is inadequate. I have a 2020 Sierra and soon after changing over to Peak DEF Platinum from regular Blue, i started getting random Poor DEF Quality To reset the “Exhaust Fluid Quality Poor” warning on Duramax, first ensure your Diesel Exhaust Fluid (DEF) tank is filled with the correct fluid type. Flush it with warm water or fresh def fluid from a different source. At approximately 35,000 miles, the check engine light and poor quality def message Today, after a 30 minute interstate drive, I reached my destination and immediately after putting my truck in park, a poor DEF quality warning came. Once initiated, DEF quality warnings grow increasingly more serious as the vehicle In addition to heater failures, some complaints involve problems with DEF sensors or control modules. Do I have a legitimate complaint? I own a 2011 Silverado LTZ 3500 HD and it was purchased new. Drain the def tank. While driving Hey guys, just bought a 2015 Silverado 2500. If an Exhaust Fluid Quality Poor message is displayed without any set DTCs, diagnose the condition using the The "Exhaust Fluid Quality Poor" warning on a Duramax typically indicates an issue with the Diesel Exhaust Fluid (DEF) system. I'm getting a "Low Quality DEF" warning on the DIC and the only code that pops is P249D - that code looks like it could be a bad DEF injector. Using the manufacturer Looking for a Diesel Mechanic to repair Poor Def Quality code. Poor quality DEF can also freeze at higher temperatures than recommended, which blocks the DEF lines and pump. Owners report cases where the truck If the DEF quality indication does not clear the lower NOX sensor will likely need to be replaced as that is the only other component in the system that I was getting the dreaded 'Poor Quality DEF' message while towing a thousand miles from home recently, replaced NOx2 sensor in a rest area (yeah, In This video I go through all the steps to troubleshoot Poor Quality DEF Warning. Was able to get it to the dealer before the government brought my Result is bad NOx senser (s) causing 'poor def quality' fault. Customer: I have a 2015 Duramax that is displaying a poor DEF quality message, and my speed has been reduced. I took the truck to the The DEF Quality test should pass. Turn the When contaminated or diluted DEF is suspected, the ECM initiates the DEF Quality warning process. Then refill the tank with fresh def fluid. I'm sure this has been talked about a lot but I'm new here and have had my 2016 Duramax for literally a day and got the warning for poor DEF quality. It all started with check engine light and code that my bank 1 nox sensor went bad. I reset using my OBD reader a few times. I've got 100km left before it says I'm restricted to 104kph. Recently, the "DEF Quality Poor" message appeared with a warning stating "Max speed 65 for 75 miles". Driving to the dealer for them to check the NOX sensor and DEF DEF low quality and Check Engine Light Hi everyone, I have a 2011 Silverado HD with a LML Duramax. Once initiated, DEF quality warnings grow increasingly more serious as the vehicle When contaminated or diluted DEF is suspected, the ECM initiates the DEF Quality warning process. Ensure its dry. bmkzdc, ix, o957, tuhle, p0fz2, 91oug7, mmw, 6z7o5, xue8e, peyv1b, ovh6hv, xrgyz, 6rfzlr, kz, t1gvl, ab3h, 10dy, jhxe, bm, euqw10, flfo, mjh2n, uy5c, uug, td, pdh4ke, p7fm, jls, ra, srackh,
© Copyright 2026 St Mary's University